Overview

CONSTRUCTION

Homologation: CE Cat A
Ta Yang Yacht Building Ltd November 2010
Design: Hull Ladd Naval Architect – Deck, Interiors engineering Jacaroni Naval Architect, Marine Engineer

• HULL

Blue gelcoat/White Waterlines
Hand lay-up E-glass/Coremat/PVC foam sandwich (sides) 3⁄4'' thick PVC foam on hull above water line

DECK

Hand-made teak planks 10mm thickness, applied without screws on Deck House, Coach roof and Deck house.
Hand lay-up PVC foam sandwich
Teak toe rail 10 cm height with custom teak cap rail

• TANKS AND CAPACITIES

Diesel

Material: Aluminum 4,5 mm (5052H32) N°2 tanks placed under deck house sole. Total capacity 2044L

Drink water

Material: Inox AISI 314
N°2 tanks placed under deck house sole Total capacity 1173 L

Grey Water

Material: structural GRP
N°2 tanks placed under forward and main cabin sole Capacity 120 L

Holding tanks

Material: structural GRP
N°3 Tanks placed under forward and main cabin sole and on day head Total Capacity 300 L

AUXILIARY PROPULSION

Yanmar 160 HP 4LHA-HTP series
Gearbox: HURT-ZF 45A
Alternator 80 A/12V
Mastervolt alternator heavy duty 150A/24V for service batteries Shaft AISI 316 1-3/4''

Bracket: AISI 316
Hi efficency propulsion pack: SPW Propeller 4 blades 24''+ inclined shaft+ custom gear ratio MORSE bearings
VETUS BULLFLEX (antivibration shaft)
GRP waterlock
RACOR Dual-type diesel-fuel filter for engine
RACOR diesel-fuel filter for generator
Engine Double electronic Morse control (internal- External starboard position)
Safety Morse switches in engine room
S/S custom remote valves for engine and generator fuel

Engine Double control Yanmar (internal-External starboard position)
Sea Fire automatic fire extinguisher in the two machinery compartments (engine and generator)
n°3 Jabsco Electric ventilators for machinery compartment and engine room
2'' aluminium sound absorbing veneer insulation surrounding machinery compartments Sidepower bow propeller SP155 TCI- 24V
Westerbeke 12.5 EDT 514 230V 50Hz Generator with NMEA 2000 databus
Sound guard SST soundproof system with separate exhaust silencer
N°2 Reverso Oil change systems for engine and generator
Fuel transfer pump between tanks both for water, both for fuel systems.

STEERING SYSTEM

Inox Shaft AISI 316
FRP Fully protected skeg-hung rudder (not hydrodinamically balanced) Edson Independent two-cable steering
Emergency tiller
N°2 Lewmar Minimaxi bi-spoke 42'' steering wheels covered

ANCHORING SYSTEM

N°2 s/s windlasses Maxwell VWC 3500 24V(vertical on deck with integrated warping winch)
n°2 * 100 m high load 10mm DIN calibrated chains by Maggi Catene
n°2 CQR stainless steel 316L 55 kg custom anchors

Double chain locker with chain stoppers
Custom folding Anchor roller for automatic pull down of 2 CQR anchors
N°2 remote controls Lewmar stations with evolved functions mod.AA550, chain release function

GENERAL LAYOUT

Deck House with internal steering post. Raised saloon.
Cockpit with double steering, wide Teak table (hi gloss coated) drop leaf
with central section and pod for G120+keyboard and yanmar engine control panel
type C
Twin custom GRP pedestals with Ritchie compasses: port station dedicated to sails controls (4 joysticks), starboard station dedicated to manouvering
Teak companionway doors with handle and lock by “Foresti e Suardi”
Bimini top 20 sqm inox retractable
Stainless steel 316 stern pulpit up to lateral entrances and 2 teak lateral seats
Stainless steel 316 bow pulpit
Stainless steel 316 stanchions and guard rails
Stainless steel 316 custom oval base pipe
Stern mast S/S for folding Radar- satellite antenna-horn-CAM100-speaker

Wide afterpeak with ladder flush deck hatch
Wide forepeak with ladder flush deck hatch
Deep lateral port peak with flush deck hatch
Deep cockpit peak for life raft and liquid storage with flush deck hatch
Structural teak rub rail for longitudinal strenght and s/s 316 plank running along topsides
Fixed lateral port-holes Manship Inox 316 size 1
Screens for port holes
Opening lateral port-holes Manship Inox 316 size 1 in forward, centerboard and aft bathrooms.
N°8 Low Profile Manship luxury hatches Inox 316
Emergency escape for main cabin below the cockpit seat and fwd shower (CE)
Reverse custom stern bathing platform with 3 curved steps, integrated custom swimming ladder and box with shower
N°8 s/s Inox mooring cleats
Electro-hydraulic external-retractable custom gangway (teak-aluminium blue coated)
3 meters with remote control

DECK HARDWARE

N°2 electric Winches Lewmar 65SEST s/s 316 for halyard and self-tacking genoa N°2 electric Winches Lewmar 77SEST s/s 316 for gennaker and mooring. Lewmar traveller cars, tracks for genoa and main sheet
Hardware Lewmar for: cars, tracks, blocks, rope clutches.

Electric furlers Bamar with joystick controls on port pedestal and emergency Boxtron (2nd mainboard )

INTERIORS

Stern main cabin with Queen size berth and leather couch, bathroom with wooden fittings, independent shower stall, table with chair.
Bow symmetrical cabins with side double berths, bathrooms with wooden fittings, shared shower stall, table with chair

Crew cabin with 1+1 berths under living room at the centre of the boat

Day head with shower and sink for crew
Raised saloon (view from Deck House windows) with hi gloss table murple burl Raised internal steering post. with leather seat for two

Independent kitchen without door and with electric aspiration
Pc area underneath internal steering with table, leather armchair, main
switchboard and bar on bulkhead
Main engine room
Second Machinery compartment for generator and auxiliary with access on the side of the saloon
Lazarette area for large storage
Forward area for storage

SPECIFICATIONS

Poliurethane satin varnishing 50%
Hand-finished Full Teak: bulkheads and doors, trim plates.
Polished, bi-colour saloon table
Burr instrument pod of internal steering
Internal teak coating of deck house and of windows frames
Full oak internal floor (10 mm) with elegant fair wooden contours finishing (bathrooms included)
Solid floor boards with looks
Full teak grating for shower stalls
Corian countertops for bathrooms (cod. MH503)and kitchen (MM 704)
Removable ceiling panels with vinyl headliner and teak planks
Mirror PVC top panel of bathrooms
Custom climate water chilled control system with custom air outlets in bathrooms by Cruisair.

Kitchen equipment

Miele 220V Stand up fridge with freezer
4 burner cooktop with Force 10 s/s oven
S/S microwave oven Miele
Automatic gas safety shut-off valve in external LPG storage compartment Miele 220V coffe-maker

Miele 220V Dishwasher with separate Jabsco drain box Macerator with separate drain
Cover for stove

Others:
Electric sliding curtains for deck house and Manual curtains for portlights. Soft green colour. New custom matress for berths
Beige leather covering mod.0708 for saloon, internal steering, seats
Lewmar “Roller shade screens” in all cabins and bathrooms against sunlight and
insects.
FSE Robline Cruising sheets.
Covers for cockpit table and steering wheels and winches.
Cushions “Luxury” for cockpit
n°4 Complete bathroom kit (4 pieces)
Tender crane on mast
Tender 40HP with cockpit and cushions (Disp 500kg)

PLUMBING SYSTEM

Pressurised hot and cold water with 24V Jabsco & Flojet pump with automatic water sensor(rigid circuit). 220V Seaward Electric boiler with heat exchanger connected to the main engine with switch valves. Ceramic sinks with single-lever taps for bathrooms
Variable led marine faucets
S/s double sink with single-lever taps and pull-out sprayer for kitchen
N°3 internal showers and n.1 pull-out shower with hot and cold water for stern
spoiler
Sea Recovery Ultrawhisper modular water-maker mod. UW300 24V with
selfwashing
Miele 220V Washing machine
Deck wash down with two Jabsco outlets: on cockpit (flexible pipe) and near bow chain lockers (flush mounted outlet on deck)
Henderson manual pumps for Lazarette, engine and main saloon bildge compartments
n°3 24V electric pumps (Jabsco) with filter for holding tanks drain with on/off switch
N°4 Vacuflush toilets with electronic remote control Sealand 4800
Fresh water tanks vents
Holding tank vents overboard Vetus and odour filter
Tank master and tank tender with key and automatic drain by Dometic
n°2 24V electric pumps (Jabsco) and macerator
Air pressure Tank tender for fuel and water tanks
Fuel tank vents
Sea water inlets for watermaker, water pumps and auxiliary.
Water transfer pump between tanks

ELECTRIC SYSTEM AC 220V 50 Hz DC 12V & 24V

Solar panels 24 V 300w, solar charge master and automatic day/night sensor switch on electric panel for anchor lights, spreaders lights, nav lights, engine lights.
Custom electric panel with digital displays for:
AC Volt, DC Volt, DC Amp(Battery selected),

Mastervolt COMBO Charger/inverter 24V/4000W 220V 50Hz with remote control panel Mastervolt electronic charger 24V for alternator 150 A
AC Switch for: Shore-Generator-Inverter
Main switches and electrical parts by Lewmar

Mastervolt Battery isolator between battery banks and engine alt. Marinco receptacle and shore power socket
Newmar Galvanic isolator for shore power earth ground galvanic corrosion 220V schuko sockets in all spaces and below cockpit table

n°2 Mastervolt DC 24V-12V converters
12V sockets in nav station, engine room and below cockpit table Ticino Axolute series plugs and switches with led courtesy lights

Faraday gauge and grounding: isolation from lightnings and grounding system
All metal parts are interconnected
Grounding of all metal parts zinc protected by 6 anodes flush mounted on the hull

Heavy Duty Accumulators:
Engine and Generator: according to the producer's specifications House bank AGM: 4*200 Ah 12V
Inverter Bank AGM: 4*200 Ah 12V
Bow Thruster e winches AGM: 4*200Ah 12V

Lighting:

Overhead led lights: Cantalupi Tony L
Cantalupi ZEUS (living-room)
Reading lights
Cantalupi ASTOR (Foreward cabin starboard side and crew cabin) Cantalupi ONDINE (Foreward cabin port side and main cabin) Led courtesy lights color red on 3 cabins

Courtesy Led tube on Deck House sides, steps, portlights on cabins Hanging locker lights
n°6 spreaders led lights top mounted for mast (RGB variable colours) Lazarette and engine room lights

Navigation Lights: Aqua Signal
Deck lights: Aqua Signal
Cockpit lights: n°4 Catalupi Tony L ext, near hood and steerings,n°2 blue colour led strips IP65, n°2 alogen spot lights (1 Million cdl) on rollbar.
Table lights: n°2 osculati led
Cockpit led lights on table.
Transom lights with: n°1 underwater light
Lateral bow lights with n.2 underwater lights

Climate control system:
Cruisair water chilled, with 4 climate controls and handlers with outboard drain Ventilation available without switch on the Generator
Webasto DBW 2010 – 24V diesel heater integrated

n°2 LCD 20'' Samsung TV white color integrated on the ceiling of the fwd cabins, manually sliding n°1 LCD 32'' Hisense TV fixed on bulkhead for owner's cabin
n°1 LCD 15'' Hitachi TV for 4th cabin sliding on bulkhead

Raymarine electronics:
Pack Autopilot:
Control unit ST 7002/S3 Corepack/T3 Linear Hydraulic actuator Complete Electronic Pack :
N°1 processor GPM400 G series
N°1 Monitor G150 for dashboard internal steering
N°1 Monitor G120 for cockpit table
N°2 Complete keyboards for Monitor G series
N°1 GVM400 audio-video unit
N°1 Antenna gps Raystar
N°1 Antenna radar radome 48 HD digital 4 Kw (MARPA)
N°2 Videocameras cam 100 ccd for anchors and bow/stern pulpit
N°1 Trasponder AIS 250
N°1 Graphic Sonar HD DSM30 unit
N°1 Transducer 1Kw HD depth' bulb
N°1 Tranducer speed/temp
N°1 Transducer anemometer
N°4 ST 350 CI monitor for steerings
N°1 Smartcontroller wireless for remote autopilot control and nav data. N°1

Steering Joystick for internal steering
N°2 VHF 240E with interphone, hailer, fog horns
N°2 Lifetag, safety bracelets MOB

N°1 Satellite TV system Ray 45STV Europe with n°5 outlets yet wired N°2 Horn buttons on ext/int. Steering post

ALARMS:
Sicurit Alarm Italia complete system with remote control

Local tracking system by SMS